|
02-28-2016, 11:01 AM
|
#1
|
Winnebago Camper
Join Date: Feb 2016
Posts: 5
|
2012 Journey Chassis batteries
We just recently purchased a 2012 Journey 34Y and we love it. The problem I am having is my chassis batteries are draining at home with the shore line plugged in. According to what I can read the shore line should be charging the chassis batteries as well as the house batteries. The house batteries are about 13.5v and the chassis batteries are at 12.8.
Thanks Alan
|
|
|
02-28-2016, 11:46 AM
|
#2
|
Winnebago Camper
Join Date: Oct 2014
Location: Layton, Utah
Posts: 24
|
12.8 ain't bad, but it is my feeling that some mh charge their chassis batteries and some, like mine, do not because a) it was never set up to do so or 2) something is broke. As long as they don't drain too much (define this yourself) who cares! My owners manual never mentions charging the chassis from shore, so I'm in category a) above I believe. Do you use your disconnect switch when stored?
__________________
Cheers,
TonyMac
2006 Monaco Safari Cheetah 40PMT
|
|
|
02-28-2016, 12:43 PM
|
#3
|
Winnebago Owner
Join Date: Jul 2014
Posts: 200
|
If you read in the MH literature that the chassis battery should charge, then it should.
Here is a test.
1, Un-plug the MH and start the engine. Let it run 10 minutes.
2, Still running, test the battery voltage at the start battery and the house battery.
If they are the same ( 13 + volts), all is well and it does not charge while plugged in. It is a one direction type system.
If the volts are different, then it may be a bi-directonal system and the magnetic switch ( solenoid ) is not working.
Do the test and report back.
|
|
|
02-28-2016, 02:44 PM
|
#4
|
Winnebago Camper
Join Date: Apr 2012
Posts: 11
|
We have an older 34H that has an inverter/charger that only charges the house batteries when connected to shore power so I had to use a separate auto charger once a week for the 2 chassis batteries until I found the Trik-l-start that bleeds off the house charger into the chassis batteries.
Our chassis batteries always read a little less than the house (when not connected to shore power) because they are the sealed type and not the same as the house deep cycle lead acid which read slightly higher. I understand later model coaches have the ability to charge both battery banks as standard equipment.
|
|
|
02-29-2016, 05:54 AM
|
#5
|
Winnebago Owner
Join Date: Aug 2013
Posts: 74
|
We have a 2013 Journey and it has a BIM (Battery Isolation Manager that closes a solenoid and charges the chassis battery when on shore power and charges house batteries when engine running, and ours failed and stopped charging chassis batteries. I attached the troubleshooting document if the 2012 does have the BIM.
Also precision will repair and ship back for free if you contact them about repair.
Paul
__________________
Paul & Debbie
2013 Journey 42E
|
|
|
02-29-2016, 07:15 AM
|
#6
|
Winnebago Master
Join Date: Nov 2004
Location: On the Road Westward
Posts: 711
|
On ours the Inverter/charger will charge the chassis battery but not constantly. It monitors the battery and will charge it when it falls below a preset voltage. (Called a Smart Battery Combiner)
You can check this by turning ignition key to accessory and running defrost fans. The chassis battery voltage on the oneplace monitor should rise to coach battery voltage after a bit of time.
__________________
Dan & Sharon & Kasey (Our Yorkie Puppy (12 Yrs Old) On the Road (2012 Journey 36M, 2006 Jeep Liberty)
USN-Ret ('65-'93) Fulltimers, Class of 2012
|
|
|
02-29-2016, 07:35 AM
|
#7
|
Winnie-Wise
Join Date: Mar 2007
Location: Apex, NC
Posts: 449
|
In 2010 34y models the chassis battery is charged while on shore power by a Trik-L-Start. These were factory standard. Your 2012 model should definitely be charging the chassis battery. I don't know though what method Winnebago used in later models like yours. What you're seeing may be normal. I would keep an eye on the chassis battery voltage and if it drops to 12.5 volts or less, I'd be concerned. A fully charged battery is 12.6 to 12.8 volts.
__________________
2010 Winnebago Journey Express 34Y
2010 Freightliner XCS (mfd 9/'09)
'07 Saturn Vue V6
|
|
|
02-29-2016, 08:59 AM
|
#8
|
Winnebago Camper
Join Date: Feb 2016
Posts: 5
|
Thanks to all of you. The journey does charge the chassis batteries but not until the voltage drops to about 12.5. I ran the battery down and it charged up to 13.4 matching the house batteries. I was just being a paranoid newbee. Thanks again
|
|
|
03-01-2016, 04:00 PM
|
#10
|
Former Winnebago Owner
Join Date: Jun 2008
Posts: 69
|
grtharris,
Thanks for posting this info. I have a 2011 Meridian 34Y and have been looking for a Trik-L-Start but couldn't find one. Now I know why :-) The BIM looks to be a very sophisticated device, much more so than the Trik-L-Start.
__________________
Albert Irusta
2011 Itasca Meridian 34Y
2006 Jeep Liberty
|
|
|
03-02-2016, 09:36 PM
|
#11
|
Winnebago Master
Join Date: Jun 2013
Location: Full-timer/volunteer w/SOWERS
Posts: 2,734
|
Quote:
Originally Posted by Alann5910
We just recently purchased a 2012 Journey 34Y and we love it. The problem I am having is my chassis batteries are draining at home with the shore line plugged in. According to what I can read the shore line should be charging the chassis batteries as well as the house batteries. The house batteries are about 13.5v and the chassis batteries are at 12.8.
Thanks Alan
|
Hi Alan. If no one has said :welcome:
I hope I am the first.
You may not be having a problem. The charging system will switch to the low battery when needed. 12.8V is a good charge. Mine, at this moment is 12.6 and the house battery is in the Absorb charge routine at 14.7V.
You have a relay that selects the battery needing charging. One charger, two battery banks isolated from one another. Just follow the charging several times a day over a couple of days. You should see good things happening.
Happy trails,
Rick Y
__________________
Rick & Melissa Young & Dawson (RIP), 2011 Meridian 40U, FL XCL, ISL 380HP/DEF, Al 3000 MH, 2014 Honda CR-V, SMI AF1, Blue Ox TruCenter & tow equip.,EEZTire TPMS.
Servants On Wheels Ever Ready. Best job we ever paid to do . (full time volunteers)
|
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Thread Tools |
Search this Thread |
|
|
Display Modes |
Linear Mode
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|