Maybe this will help.....
Thought I would pass on what I found in troubleshooting the 12V Power Distribution Center on my '04 National Dolphin 5320. Mine uses the board #129757.
Problem:
- Coach batteries not being charged by alternator.
- Chassis battery not being charged by house battery charger.
- Can't hear soleniod operating
Diagnosis:
- Confirmed F32 3A fuse was good, replacing fuse operated the Interconnect Solenoid (loud clunk). Therefore solenoid was activated already but not passing current between batteries.
- Confirmed there was battery voltage on solenoid small terminals.
- Measured across the solenoid large terminals - 1.3V drop across contacts; this should be near 0 Volts.
- Tapped the solenoid case sharply and measured again, now .2 Volt drop.
- Confirmed chassis battery is now being charged by battery charger.
Fix:
Contacts inside solenoid are bad. Replace with Napa ECH ST85 or equivalent CONTINUOUS DUTY solenoid. (disconnect house and chassis batteries before attempting this)
It isn't always the control board.
Attached Thumbnails