RV Trip Planning Discussions

Go Back   iRV2 Forums > THE OWNER'S CORNER FORUMS > National RV Owner's Forum
Click Here to Login
Join iRV2 Today

Mission Statement: Supporting thoughtful exchange of knowledge, values and experience among RV enthusiasts.
Reply
 
Thread Tools Search this Thread Display Modes
 
Old 05-13-2014, 08:00 PM   #1
Junior Member
 
jpbill's Avatar
 
Join Date: May 2014
Posts: 2
Power Gear Leveling Neutral Safety Switch Problem

Hello. Newbie here. I have a 2005 Seebreeze Lx. The leveling system is Power Gear Manual Hydraulic. The Control Panel is #500731. They have worked flawesly since I purchased it new on 8/2004. In preparing for a trip I tried to level the MH. When I pressed the power on button the Power Led light and the wait Led light began to blink. Yes the hand brake is on. Yes the hudraulic fluid level is OK. And yes the MH is in Park. I contacted Power Gear and they said the blinking power light and the blinking wait light was indicating that the Heutral Saftey Switch was not being detected. They said to check the six point main Power Connecter. The number 2 pin and the number 6 pin indicate the Neutral Saftey Switch. They should both test the same either both Neg Ground or Pos Power. I checked mine and the number 2 pin was Neg Ground the number 6 pin was Pos Power. OOPS. Now it gets tough. What is the fix for this. Power Gear says it is a Chasiss problem which is Workhorse and Workhorse says it is a power gear Problem. . There appears to be no problem with the Neutral Safety Switch as the MH Engine would not start if it was defective. So I turn to the people here who may have had the same problem and somehow found the solution
__________________

jpbill is offline   Reply With Quote
Join the #1 RV Forum Today - It's Totally Free!

iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!

You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!

Old 05-14-2014, 07:02 AM   #2
Senior Member
 
Workhorse Chassis Owner
Join Date: Sep 2007
Location: st.charles mo.
Posts: 1,294
On my 05 work horse chassis it doesn't use the nutral saftey switch but it does use the parking brake switch.
__________________

speed racer is offline   Reply With Quote
Old 05-14-2014, 09:53 AM   #3
Senior Member
 
hydro45640's Avatar
 
National RV Owners Club
Workhorse Chassis Owner
Join Date: Apr 2013
Location: Jackson,Ohio
Posts: 299
Check the switch that is attached to the emergency brake pedal. My 5355 dolphin does the same thing, when I wiggle the spade connector the system starts to work correctly. the switch has only one wire that furnishes the ground for the levelers. It is not hard to find after you get in the tight space.
hydro45640 is offline   Reply With Quote
Old 05-14-2014, 10:39 AM   #4
Junior Member
 
jpbill's Avatar
 
Join Date: May 2014
Posts: 2
Thanks for the thoughts. I don't think in my case it is the Brake switch as there is a seperate LED light for the parking brake and it will come on if I disengage the parking brake and go off when I reingage the parking brake.
jpbill is offline   Reply With Quote
Old 07-19-2014, 12:52 PM   #5
Junior Member
 
Join Date: Jul 2014
Posts: 2
have97 discovery jacks don't work pumpruns but nothing happens
brnegg50 is offline   Reply With Quote
Old 07-21-2014, 05:07 PM   #6
Senior Member
 
Fred and Bonnie's Avatar
 
Workhorse Chassis Owner
Join Date: Jan 2002
Location: Pacific Northwest or SoCal
Posts: 2,903
Send a message via ICQ to Fred and Bonnie
We had the same issue in 2009, Redlands Truck repaired the ground wire for the neutral switch wiring.

Fred
__________________

__________________
Fred and Bonnie
2005 Dolphin LX 6375
Abby, Ruffles & Scarlett, "The Cats"
Fred and Bonnie is offline   Reply With Quote
Reply

Tags
leveling, power, power gear, safety



Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
Power Gear jacks and parking brake danes-on-tour Monaco Owner's Forum 27 05-17-2014 05:09 AM
power gear levelers ram1242 Class A Motorhome Discussions 7 04-21-2014 07:44 PM
Leveling jack problem minnick888 Class A Motorhome Discussions 4 03-28-2014 04:38 PM
Oil reservoir? and power switch? jimbo2013 Monaco Owner's Forum 3 12-19-2013 08:58 AM
2002 tiffin phaeton pump switch power foss1619 Class A Motorhome Discussions 3 09-10-2013 11:25 AM

» Featured Campgrounds

Reviews provided by


Copyright 2002- Social Knowledge, LLC All Rights Reserved.

All times are GMT -6. The time now is 03:44 AM.


Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2018, vBulletin Solutions, Inc.