|
|
02-08-2018, 04:49 AM
|
#1
|
Senior Member
Monaco Owners Club
Join Date: Aug 2017
Location: Orlando, Florida
Posts: 5,819
|
HWH warning light and dropping out of Travel mode while driving
While driving today, my dash warning light "HWH Warning" came on. I looked at the HWH leveling panel and noticed the "Travel Mode" was off.
I pressed the Travel button and the green light came on and the dash warning light went off.
About 10 minutes later the dash warning light was back on and the green Travel light was off again. So I pressed the Travel button again and the green light came on and the dash warning light went off.
This repeated every 5 or 10 minutes for the entire drive.
What is going on?
|
|
|
|
Join the #1 RV Forum Today - It's Totally Free!
iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!
You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!
|
02-08-2018, 06:05 AM
|
#2
|
Senior Member
Join Date: Jul 2006
Location: Boise Valley (SW Idaho)
Posts: 2,018
|
I don't know if it will help, but the first thing I would try would be resetting the HWH system. If your coach is like our '06 Dynasty, there is a reset button mounted in the upper, aft corner of the front run box. It is labeled HWH Master Warning Light and Reset Switch. It might be good to pull over and try it as soon as you can after it goes out of the travel mode you are experiencing. I do doubt if you are at risk of having the suspension come down quickly when that is happening, but it's not impossible, so I would definitely keep at it until you find the root cause and stop it from happening more.
__________________
Jim & Angie, Boise, ID
2021 Entegra Esteem 27U
2017 GMC Acadia Denali
|
|
|
02-08-2018, 06:07 AM
|
#3
|
Member
Monaco Owners Club Vintage RV Owners Club
Join Date: Oct 2017
Location: Arizona
Posts: 92
|
Oh. I'd suspect a jack is bouncing down a little from the stowed position. That would indicate either weak return springs on the jack, debris retarding the jack, or the jack cylinder not compreeing all the way down. Or even the sense switch.
When the dash warning light comes back on, take a broomstick and go around and try pushing the jacks up one by one checking the dash light each time to find the problem child. Usually it's just a slight bit frome properly stowed position.
|
|
|
02-08-2018, 07:03 AM
|
#4
|
Senior Member
Monaco Owners Club
Join Date: Aug 2017
Location: Orlando, Florida
Posts: 5,819
|
Thanks for the advise.
@Mike, I have the RVA (3-point) hydraulic leveling jacks and the HWH Air Leveling, are these two systems communicating with each other, or did you think the hydraulic and air levelers were both HWH?
|
|
|
02-08-2018, 07:10 AM
|
#5
|
Member
Monaco Owners Club Vintage RV Owners Club
Join Date: Oct 2017
Location: Arizona
Posts: 92
|
I have a knee jerk reaction when I see HWH and immediately think of the physical jacks. I forget or had missed that they make air leveling as well.
|
|
|
02-08-2018, 07:11 AM
|
#6
|
Member
Monaco Owners Club Vintage RV Owners Club
Join Date: Oct 2017
Location: Arizona
Posts: 92
|
Plus. I'm up early.
|
|
|
02-08-2018, 12:02 PM
|
#7
|
Senior Member
Monaco Owners Club
Join Date: Oct 2009
Location: Tucson, AZ
Posts: 6,579
|
I agree with Jim. First I hit the reset button, then if that doesn't work I turn the ignition off for 10 seconds and then back on.
HWH is very responsive when you send parts in for repair. I sent my leveling panel in and they rebuilt it and had it back in a few days. Next up I need to figure out why it will not auto level.
__________________
97 Monaco Windsor- Sold
07 Monaco Executive McKinley- Sold
04 Monaco Signature Chateau IV
|
|
|
02-08-2018, 12:59 PM
|
#8
|
Senior Member
Monaco Owners Club
Join Date: Aug 2017
Location: Orlando, Florida
Posts: 5,819
|
I'll try the HWH reset. I can do that before I leave the campsite tomorrow.
Once I'm driving, if the travel light goes out and HWH warning come on, I can't get to the reset switch unless I pull over somewhere. But hitting the Travel Mode button does seem to have some effect, and that is easier and probably safer than pulling over on I-95.
I will also call HWH when I get home and see if they have any ideas on what to test/do.
Thanks
|
|
|
02-08-2018, 03:37 PM
|
#9
|
Senior Member
Monaco Owners Club
Join Date: Apr 2010
Location: Saint Leonard,MD
Posts: 750
|
The default mode is travel so I would not worry while traveling. That is the failsafe mode. That is the mode if you pull the fuses on the HWH. Call HWH as you already mentioned. I have a lot of exparience with HWH air leveling. Feel free to PM me. Us CAT owners need to stick together
__________________
2005 Safari Panther Diamond IV Cat C13
2013 Avalanche Toad
|
|
|
02-09-2018, 07:25 AM
|
#10
|
Senior Member
Monaco Owners Club Vintage RV Owners Club Holiday Rambler Owners Club
Join Date: Jul 2012
Location: Lexington, SC
Posts: 2,820
|
Contact Paul at AZPETE on the Irv2 forum. He works for HWH and can answer your questions. His email is pfmaddox@att.net and his phone number is 602-549-3638. He is a Commercial Member and has posted that his phone is always on, and if not answered, leave a message.
He has helped other on this forum and I am sure he can help you
__________________
Vera & Ken
1998 Holiday Rambler Imperial, RR8S Chassis
Cummins 6C8.3 mechanical engine, 325HP, 3060 Allison
Towing 2014 Ford Explorer
|
|
|
02-09-2018, 02:46 PM
|
#11
|
Senior Member
Monaco Owners Club
Join Date: Aug 2017
Location: Orlando, Florida
Posts: 5,819
|
Quote:
Originally Posted by veraken
Contact Paul at AZPETE on the Irv2 forum. He works for HWH and can answer your questions. His email is pfmaddox@att.net and his phone number is 602-549-3638. He is a Commercial Member and has posted that his phone is always on, and if not answered, leave a message.
He has helped other on this forum and I am sure he can help you
|
Thanks.
I sent him a PM and e-mail. I hate to "call" someone for help and interrupt them - that will be my last resort.
|
|
|
02-10-2018, 06:31 AM
|
#12
|
Senior Member
Monaco Owners Club Vintage RV Owners Club Holiday Rambler Owners Club
Join Date: Jul 2012
Location: Lexington, SC
Posts: 2,820
|
Quote:
Originally Posted by CountryB
Thanks.
I sent him a PM and e-mail. I hate to "call" someone for help and interrupt them - that will be my last resort.
|
If he didn't want you to call him, he would not have posted his phone number
__________________
Vera & Ken
1998 Holiday Rambler Imperial, RR8S Chassis
Cummins 6C8.3 mechanical engine, 325HP, 3060 Allison
Towing 2014 Ford Explorer
|
|
|
02-10-2018, 06:55 AM
|
#13
|
Senior Member
Join Date: Feb 2013
Posts: 558
|
veraken I agree with you. They used to call it snail mail now it is called email. The man may not have time to email which is why he said "call me" so he could address the problem and ask questions WAY quicker.
__________________
2002 Beaver Marquis Emerald C-12 Cat 505 HP towing 2004 Honda CR V with 300K on clock
2014 Volvo 630 Heren Bed ET Hitch SOLD
2017 New Horizons Majestic 35 foot SOLD
|
|
|
08-20-2018, 12:04 PM
|
#14
|
Senior Member
National RV Owners Club Freightliner Owners Club
Join Date: Dec 2008
Posts: 117
|
Same problem
Mike!
I am having the same problem with the HWH air leveling on my '06 Beaver Monterey. It drops out of Travel mode while going down the road. Did you resolve the issue with yours?
Thanks.
Richard
|
|
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|