Go Back   iRV2 Forums > MOTORHOME FORUMS > Class A Motorhome Discussions
Join iRV2 Today

Mission Statement: Supporting thoughtful exchange of knowledge, values and experience among RV enthusiasts.
  This discussion is proudly sponsored by:
Please support our sponsors and let them know you heard about their products on iRV2
Thread Tools Search this Thread Display Modes
Old 01-01-2011, 06:03 PM   #1
Junior Member
Join Date: Apr 2010
Posts: 5
Air Suspension

I am working on a 2002 DS-01 Travel Supreme 38". Every time the customer stops for fuel, by the time he is finished fueling the front suspension loses all of its air and drops the front end. The only audible air leak is from the air ride leveling vale in the rear. This air leak lowers the secondary air tank to 65 psi. then quits. I can't figure how the rear air bags can effect the front air bags. I would appreciate any feedback concerning my problem.

BertCar is offline   Reply With Quote
Join the #1 RV Forum Today - It's Totally Free!

iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!

You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!

Old 01-01-2011, 06:39 PM   #2
Senior Member
KIX's Avatar

Join Date: Dec 2006
Location: St. Augustine, FL
Posts: 3,579
A Wild A__ Guess...........
When the rear lowers could the front then be dumping air to re-level I would think you should be air tight if the coach is simply stopped.

'02 Ultimate Advantage 40J Spartan MM - Cummins ISC
2013 Jeep Rubicon JK Unlimited
KIX is offline   Reply With Quote
Old 01-01-2011, 06:41 PM   #3
Senior Member
Ann n Gene's Avatar
Join Date: Apr 2004
Location: Stillwater, Ok
Posts: 2,799
Likely the problem is in the automatic leveling system. It works by first dumping the air in the front air bags before lowering the hydraulic rams. I would start by checking the Hadley air leveling system controls and then move to the air/hydraulic system. It sounds like there may be a relay stuck that is dumping the air in the front bags in anticipation of leveling the coach. All just my opinion and experience with my 07 travel supreme.
2015 Entegra
Cornerstone 45B
2014 Lincoln MKT
Ann n Gene is offline   Reply With Quote
Old 01-01-2011, 07:22 PM   #4
Senior Member
azloafer's Avatar
Winnebago Owners Club
Join Date: Oct 2009
Posts: 1,170
We had a problem airing up after being parked . It was taking way too long after we had motion control units added to the air lines. It was inspected at the Tucson Freightliner Shop and they said that they could not find a leak, but it drove great after the air was at a drivable level and maybe the MCU's made it air more slowly. Just the front dropped like yours did. Then we took the coach to the Winnie dealer in Tucson. The service advisor was sitting at his desk in the office. He looked out the window and said, "I can see that you have a leak in the front air lines." He made this observation without getting up. A check of the coach revealed that one of the MCU's in front was improperly installed and caused an air leak. It was replaced along with a section of the air line and all was well. How Freightliner could miss this I don't know. I would have the air lines checked. The leak might not be loud enough to hear, just like ours. Happy Travels , Joe
2008 Itasca Latitude 39W. Cummins ISB 6.7 Turbo 340HP. Allison 6 Speed. Freightliner XCS. Michelin XRV 255/80R 22.5 LRG. SuperSteer MCU. Safe-T-Plus.
azloafer is offline   Reply With Quote

Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off

Similar Threads
Thread Thread Starter Forum Replies Last Post
Low Air Suspension Issue OldForester Alpine Coach Owner's Forum 85 02-15-2013 09:54 AM
Grand Star air suspension cmac41 Newmar Owner's Forum 5 09-01-2010 08:57 AM
Help! Rear air suspension won't charge Dyno Bill MH-General Discussions & Problems 3 04-20-2010 04:16 PM
Air Suspension nsdienes Winnebago Industries Owner's Forum 6 12-01-2009 02:43 PM
Adding suspension air bags to leaf springs DickP Workhorse and Chevrolet Chassis Motorhome Forum 6 08-09-2009 11:32 AM

» Virginia Campgrounds

Reviews provided by

Our Communities

Our communities encompass many different hobbies and interests, but each one is built on friendly, intelligent membership.

» More about our Communities

Automotive Communities

Our Automotive communities encompass many different makes and models. From U.S. domestics to European Saloons.

» More about our Automotive Communities

Marine Communities

Our Marine websites focus on Cruising and Sailing Vessels, including forums and the largest cruising Wiki project on the web today.

» More about our Marine Communities

Copyright 2002-2015 Social Knowledge, LLC All Rights Reserved.

All times are GMT -6. The time now is 04:50 AM.

Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2016, vBulletin Solutions, Inc.