Journey with Confidence RV GPS App RV Trip Planner RV LIFE Campground Reviews RV Maintenance Take a Speed Test Free 7 Day Trial ×
RV Trip Planning Discussions

Go Back   iRV2 Forums > MOTORHOME FORUMS > MH-General Discussions & Problems
Click Here to Login
Join iRV2 Today

Mission Statement: Supporting thoughtful exchange of knowledge, values and experience among RV enthusiasts.
Reply
  This discussion is proudly sponsored by:
Please support our sponsors and let them know you heard about their products on iRV2
 
Thread Tools Search this Thread Display Modes
 
Old 06-10-2010, 08:51 PM   #1
Junior Member
 
Winnebago Owners Club
Join Date: Jan 2010
Posts: 23
Disappointed with Super Steer MCI

I recently ordered MCI units from Henderson's in Oregon. I ordered them because of the good comments I read on this forum about what a difference it made in the way their coach performed. I talked to the parts guy at Henderson's and he asked me if my coach was over 30,000#. I told him it was 24-25,000#. He said he would send me the 6565 for the front air bags and 6575 for the rear. They arrived and I easily installed them. I am on a trip to South Dakota and I can tell you that my 36' Winnebago Journey on Freightliner chassis now rides like a log wagon. It bounces up and down like an over inflated basketball. While it may have helped on the side to side rocking motion, I am paying for it in comfort. I guess I should have gone with a sway bar. Has anyone else had this bad experience? I am tempted to take these devices off, but they did cost a lot of money. Any advice on what might help would be appreciated. My air pressure is around 110#. Is there an adjustment on this?
embmac is offline   Reply With Quote
Join the #1 RV Forum Today - It's Totally Free!

iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!

You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!

Old 06-10-2010, 09:16 PM   #2
Senior Member
 
Sammie's Avatar
 
Tiffin Owners Club
Join Date: Jun 2006
Location: Southern California
Posts: 1,808
Not knowing what year your coach is or how many miles are on it, my best guess would be that your shock absorbers are bad. I have the MCU's on my 2006 Journey and they are one of the best improvements Iv'e made. I also got rid of the stock shocks and installed Koni's. Now my coach rides smooth as silk. Your air bag pressure is not adjustable but you can also gain a better ride by getting a four corner weight and adjust the tire pressure according to that weight rating.

Sammie
__________________
2015 Tiffin Bus 37AP
2022 Jeep Grand Cherokee
"A Job Begun is Half Done"
Sammie is offline   Reply With Quote
Old 06-11-2010, 09:44 AM   #3
Junior Member
 
Winnebago Owners Club
Join Date: Jan 2010
Posts: 23
Thanks Sammie,

My coach is a 2001 Journey DL 36'. It has 55,000 miles on it. I bought it used and it had 39,000 on it. It has never steered well even though it has the Howard Steering System on it. I noticed a big difference in the ride after installing the MCI. It is a very bumpy, bouncy ride. Maybe it does need new shock absorbers. I know that everyone raves about the MCI, but mine just didn't seem to make much difference other than a little better on rocking motion.
embmac is offline   Reply With Quote
Old 06-11-2010, 07:59 PM   #4
Senior Member
 
Sammie's Avatar
 
Tiffin Owners Club
Join Date: Jun 2006
Location: Southern California
Posts: 1,808
Quote:
Originally Posted by Nancylatic View Post
Since you are in the neighborhood, stop into Precision Frame & Alignment in Elk River, MN. Like Sammie says, your shocks may be in need of replacement.

RV suspension and tires are our specialty

At the very least, go to them and get your coach weighed and the tire pressure set, and the rig greased. Get things put back to a baseline and then start adding things to it.

Precision is the best in the business AFAIK at fixing these driveability problems. Throwing parts at the problem is not the way to solve it.

Very good idea to get a baseline to start with. A front end alignment and weighing the coach is a great place to start.

Sammie
__________________
2015 Tiffin Bus 37AP
2022 Jeep Grand Cherokee
"A Job Begun is Half Done"
Sammie is offline   Reply With Quote
Old 06-12-2010, 09:55 AM   #5
Senior Member
 
GaryKD's Avatar
 
Newmar Owners Club
Join Date: Jul 2006
Location: Wellington, Florida
Posts: 13,599
Hi embmac,
I also have the MCUs and the HPSS. Like others, after installing the MCUs the handling of my coach was vastly improved. I noticed no difference in ride comfort. I also have the large Roadmaster anti-sway bar and a trac bar on the rear suspension.

It sounds like your on a path to get what is needed. Please continue to post. We can learn from what you learn.
__________________
Gary
2005 Newmar KSDP 3910 + GMC ENVOY XUV 37K lbs Moving Down The Road
The Avatar Is Many Times Around The USA
Nobody Knows Your Coach Like Somebody Who Owns One Just Like Yours
GaryKD is offline   Reply With Quote
Old 06-12-2010, 10:09 AM   #6
Senior Member
 
gmanatl's Avatar
 
Join Date: Feb 2008
Location: Hiram, GA
Posts: 160
Have you always run 110 psi in your tires? That sounds high especially for the rears. If you are overinflated it sure could cause the ride problems you are experiencing.
gmanatl is offline   Reply With Quote
Old 06-12-2010, 10:41 AM   #7
Senior Member
 
AkTrek's Avatar
 
Monaco Owners Club
Workhorse Chassis Owner
Join Date: Aug 2006
Location: Fairbanks, Alaska
Posts: 153
I too am a VERY satisfied customer of Precision Frame. They have a fully equipped shop with the friendliest and best trained people in the field we've ever met. They didn't just tune up our chasis, Dick explained every step they did. I don't think he can help the educating as he gives Chassis and Tire seminars all over the country. There is a reason you are having problems and adding parts may not only NOT work, it can often make the problems worse!
__________________
Denny & Nancy Macom • RV-Trek.com
'07 Trek29RBD Wh20/8.1 • Ultrapower • Taylor Wires • SteerSafe • SMI SIP Tow Brake
Koni Shocks • Front/RearTracBars • MotoSat F1 DataStorm • PressurePro • 02 Honda CRV
AkTrek is offline   Reply With Quote
Old 06-12-2010, 10:05 PM   #8
Junior Member
 
Winnebago Owners Club
Join Date: Jan 2010
Posts: 23
Gman,

The 110# is the air pressure going to the air bags. My tires are new Michelin XZA2 Energy. I have 90# in all 6 tires. The tires are 275/70/22.5 and are J rated. I really do need to get the coach weighed per axle. It could be that I dont even need 90# in tires with this J load rating.

Thanks
embmac is offline   Reply With Quote
Old 06-13-2010, 01:12 PM   #9
Senior Member
 
GaryKD's Avatar
 
Newmar Owners Club
Join Date: Jul 2006
Location: Wellington, Florida
Posts: 13,599
Hi embmac,
I have the same tires as you. The J rating can carry a lot of weight. I am at my rear GAWR (20K lbs) and run 90 PSI in the rear tires. The front tires call for 100 PSI as I am running a little over 11K lbs on the front axle. I am balanced within 100 lbs left and right on both axles.

All this means your rear tires are about right for a 20K lb weight. A 20K lb axle is all I have ever seen on the rear of any coach. The front tires may be a bit light, depending on the weight you are carrying.
__________________
Gary
2005 Newmar KSDP 3910 + GMC ENVOY XUV 37K lbs Moving Down The Road
The Avatar Is Many Times Around The USA
Nobody Knows Your Coach Like Somebody Who Owns One Just Like Yours
GaryKD is offline   Reply With Quote
Old 09-15-2010, 03:27 PM   #10
Junior Member
 
Join Date: Sep 2010
Posts: 10
Hi All! I just had Super Steer MCUs installed along with new shocks(Bilsteins) and new radial Michelons on my 2000 Fleetwood Discovery w/25k for mileage. This is my first MH after several TTs and I am still learning. I also added a Safe-T steering stabilizer and I can tell you that the rig handles like my Volvo and is very comfortable. The previous owner had three tires on the rig that were born in 1999 and apparently were original equipment. I would recommend not sparing a dollar to have the piece of mind to know what your driving on and I think you to will also be satisfied with Super Steer's products. Take care and drive safe...
James
__________________
My Service Dog "Annie" and I in my Army Dress Blues April 2010 at our service team graduation. Retire from the military in OCT 2010. Looking at full-timing with Annie... Drive safe everyone...
Easyrider-6 is offline   Reply With Quote
Old 09-15-2010, 07:02 PM   #11
Moderator Emeritus
 
Gary RVRoamer's Avatar


 
Join Date: Jan 2000
Location: West Palm Beach, FL. USA
Posts: 27,563
Shock absorbers really don't do much for ride comfort - they are intended to control suspension bounce and keep the wheels in contact with the road.
__________________
Gary Brinck
Former owner of 2004 American Tradition and several other RVs
Home is West Palm Beach, FL
Gary RVRoamer is offline   Reply With Quote
Old 09-15-2010, 07:18 PM   #12
Senior Member
 
Join Date: Nov 2008
Location: Bakersfield CA
Posts: 259
Replaced the stock Bilstein shocks on my '98 Safari Serengeti with Koni shocks. The change made quite an improvement in the ride quality. Prior to replacing the shocks the ride was somewhat harsh when hitting bumps, but after replacing the shocks, the ride is much smoother when encountering bumps and rough spots in the road. Even the DW noticed the difference and asked what changes I had made to make the ride smoother!
I was plesantly surprised in the difference the shocks made.
CarlGeo is offline   Reply With Quote
Old 09-15-2010, 11:44 PM   #13
Junior Member
 
Join Date: Sep 2010
Posts: 10
Quote:
Originally Posted by Gary RVRoamer View Post
Shock absorbers really don't do much for ride comfort - they are intended to control suspension bounce and keep the wheels in contact with the road.
Gary, I would say that controlling suspension bounce is a component of ride comfort. Decent shocks are part of the suspension package and do help the coach's ride.
EZ6
__________________
My Service Dog "Annie" and I in my Army Dress Blues April 2010 at our service team graduation. Retire from the military in OCT 2010. Looking at full-timing with Annie... Drive safe everyone...
Easyrider-6 is offline   Reply With Quote
Old 09-16-2010, 05:06 AM   #14
Administrator in Memoriam
 
Route 66's Avatar


 
Newmar Owners Club
Retired Fire Service RVer's
Spartan Chassis
Join Date: May 2000
Location: Newark, DE
Posts: 25,898
Quote:
Originally Posted by Easyrider-6 View Post
Gary, I would say that controlling suspension bounce is a component of ride comfort. Decent shocks are part of the suspension package and do help the coach's ride.
EZ6
I agree.

Changing from Bilstein's to Koni's resulted in a remarkable improvement in ride comfort by eliminating the harshness of the Bilstein's for the softer Koni's.
__________________
Adios, Dirk - '84 Real Lite Truck Camper, '86 Wilderness Cimarron TT, previously 4 years as a fulltimer in a '07 DSDP

Route 66 is offline   Reply With Quote
Reply



Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
Problems attaching the Super Steer Motion Control Units RV'nOldTimer Freightliner Motorhome Chassis Forum 35 02-14-2016 03:16 PM
Super Steer Motion Control Units - WOW! Warpath Freightliner Motorhome Chassis Forum 111 07-22-2013 05:45 PM
Super Steer bigstonebay MH-General Discussions & Problems 13 03-11-2010 11:32 AM
Super Steer Bell Crank NeptuneGator Workhorse and Chevrolet Chassis Motorhome Forum 6 06-03-2009 06:31 AM
Henderson Super Steer Differential Brace Bracket DriVer Workhorse and Chevrolet Chassis Motorhome Forum 28 01-30-2007 11:07 AM

» Featured Campgrounds

Reviews provided by


All times are GMT -6. The time now is 07:17 PM.


Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2024, vBulletin Solutions, Inc.