|
01-29-2016, 10:07 PM
|
#1
|
Senior Member
Join Date: Nov 2013
Posts: 290
|
Engine alarm intermittent
I have an CAT C9 engine and the engine idiot light flashes and an alarm goes off every once in a while starting yesterday. The dash reads "stop engine" but within 10 seconds everything goes back to normal. Temp is normal, oil pressure normal, transmission temp is normal. No fault codes listed at all in the diagnostic menu. Anyone have any ideas?
Bill & Christine
40 ft Revolution LE Diesel Pusher & Honda Fit Sport
Sent from my iPad using iRV2 - RV Forum
__________________
Bill Thompson
2006 Fleetwood Revolution 40 LE
2022 Jeep Cherokee Trailhawk
|
|
|
|
Join the #1 RV Forum Today - It's Totally Free!
iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!
You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!
|
01-30-2016, 07:12 AM
|
#2
|
Senior Member
Join Date: Apr 2011
Location: Powell River, B.C.
Posts: 31,500
|
With the problem only on start up , I'd think the first check would be batteries, if during the start up the voltage drops below a certain amount ; say 10.5 v ; the engine controller may be confused and not get around to proper operation , till the alternator builds the voltage back up.
__________________
99DSDP 3884, Freightliner, XC, CAT 3126B, 300 HP /ALLISON 3060
2000 Caravan toad, Remco & Blue Ox.
|
|
|
01-30-2016, 08:10 AM
|
#3
|
Senior Member
Monaco Owners Club
Join Date: Jun 2014
Posts: 14,608
|
Check coolant level also, if you have a surge type tank with level indicator it may be low enough to trigger while driving up/down hills and around corners.
__________________
Jim J
2002 Monaco Windsor 38 PKD Cummins ISC 350 8.3L
2005 Jeep Grand Cherokee w/5.7 Hemi
|
|
|
01-30-2016, 08:15 AM
|
#4
|
Senior Member
Newmar Owners Club
Join Date: Oct 2009
Posts: 10,310
|
Quote:
Originally Posted by Chiefly1
I have an CAT C9 engine and the engine idiot light flashes and an alarm goes off every once in a while starting yesterday. The dash reads "stop engine" but within 10 seconds everything goes back to normal. Temp is normal, oil pressure normal, transmission temp is normal. No fault codes listed at all in the diagnostic menu. Anyone have any ideas?
Bill & Christine
40 ft Revolution LE Diesel Pusher & Honda Fit Sport
Sent from my iPad using iRV2 - RV Forum
|
Hello Bill, I believe before a CAT engine will start, the ECM has to see oil pressure. Might try calling CAT and asking them about this, maybe a new oil pressure sensor may correct this>.......
__________________
2012 Essex 4544 2011 Jeep JK, M&G Braking, 2014 MTI 27' Hog Hauler, Wireless brake control, 2006 Ultra & 1989 Springer, 2003 Harley-Davidson
FLHR Road King Anniversary
|
|
|
01-30-2016, 08:49 PM
|
#5
|
Senior Member
Join Date: Nov 2013
Posts: 290
|
OP here... What I should have said was the problem started day before yesterday after several hours of driving. Coach batteries were at 13.6, oil pressure and engine temp normal. I'll check fluids in the morning before pulling out but this is driving me nuts!
Bill & Christine
40 ft Revolution LE Diesel Pusher & Honda Fit Sport
Sent from my iPad using iRV2 - RV Forum
__________________
Bill Thompson
2006 Fleetwood Revolution 40 LE
2022 Jeep Cherokee Trailhawk
|
|
|
02-03-2016, 10:21 PM
|
#6
|
Senior Member
Join Date: Nov 2013
Posts: 290
|
Quote:
Originally Posted by jacwjames
Check coolant level also, if you have a surge type tank with level indicator it may be low enough to trigger while driving up/down hills and around corners.
|
Your suggestion turned out to be the problem. I was two quarts low on antifreeze. The window was pink which I thought clearly showed antifreeze but really showed a dried residue... Another lesson learned. So after taking off the window and cleaning it, adding antifreeze and a new cap as the gasket was showing its age so far I'm good! Thanks again for the help!
Bill & Christine
40 ft Revolution LE Diesel Pusher & Honda Fit Sport
Sent from my iPad using iRV2 - RV Forum
__________________
Bill Thompson
2006 Fleetwood Revolution 40 LE
2022 Jeep Cherokee Trailhawk
|
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|