Community Forums

tjshively · 11-03-2010, 08:50 AM

How do I service this unit and the rest of the air system?

jerry davis · 11-03-2010, 09:30 AM

Check out this thread.

http://www.irv2.com/forums/f104/hald...ice-68351.html

Dave Fernandez · 11-03-2010, 11:37 AM

Hello & Welcome tjshively:

I am assuming you own an Alpine. It would be helpful if you provided the year and model of your Alpine since they did change a few things over the years. Even if you do not own an Alpine it is relatively easy to change the desiccant cartage. First you must drain the air in the system. The air drain is located in the engine service compartment and has two valves with one which will open to atmosphere. (NOTE: failure to drain the air can be very dangerous) Once you drained all of the air you can disconnect the air hoses at the Air Dryer and remove the bolts around the canister. Once the bolts are removed the canister will lift off and you can unscrew the desiccant cartage. Take a picture of the air dryer or take it with you to a Truck Parts store and get a new/rebuilt desiccant cartage. When I replaced mine I purchased the desiccant cartage first and had to leave a core charge which was more than the replacement desiccant cartage.
Reverse the removal procedure of the desiccant cartage and you’re done.

EngineerMike · 11-05-2010, 02:26 PM

TJ- you should have an air-purge valve by the air chuck which should be the low point for the lines/tank that sets above the rear axle. Drain the valve of any accumulated water which should be minimal, maybe every month.
Jerry's link tells you all you need to know on the air dryer service including part#