RV News RVBusiness 2021 Top 10 RVs of the Year, plus 56 additional debuts and must-see units → ×
RV Trip Planning Discussions

Go Back   iRV2 Forums > POWER TRAIN GARAGE FORUMS > Allison Transmission Forum
Click Here to Login
Join iRV2 Today

Mission Statement: Supporting thoughtful exchange of knowledge, values and experience among RV enthusiasts.
Reply
 
Thread Tools Search this Thread Display Modes
 
Old 12-30-2020, 01:16 PM   #365
Junior Member
 
Join Date: Dec 2020
Posts: 2
Hello Allison man. I have a 93 Georgie boy spartan chassis with a 59 Cummins Allison MD 3060. My parents were the previous owner of this coach and I recently discovered that it had never had rear brakes since new. I did a treadle valve replacement after learning there was no air pressure going to the Rear brake canister. Discovered that they had pinched the airline between a piece of angle iron let the seat bolts to. And it is confirmed to be done from the factory because I had to dig through the factory spray foam to get it out. Anyway since the treadle valve replacement the transmission is not shifting correctly it will not go into six gear and you have to do over 2300 for it to shift into fifth gear if you slow down below 60 it does a very hard downshift back to fourth gear. I am not receiving any kind of light for the transmission I did however replace a sending unit under the dash that goes to that junction airbox that the brake lines connect to under the dash. I cracked the other one. Could this be the cause of my hard shifting?Or should I look somewhere else?
Gb 63 is offline   Reply With Quote
Join the #1 RV Forum Today - It's Totally Free!

iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!

You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!

Old 01-11-2021, 10:08 PM   #366
Junior Member
 
Join Date: Dec 2020
Posts: 2
Hello guys,
having a issue with my Allison 3060 wtec II. Whenever i go to start the coach it is dead unless i Waite a few seconds then a crackling noise comes from the Allison relay box / tcm under the dash. Now it doesn't shift into 6th and i have to over speed to get into 5th gear. when it starts to slow a little it down shifts really hard, It really bangs into first While still moving. I found a low mile tcm with the same p#. Do i need to get it reprogramed or just install and go? Thanks for reading..
Gb 63 is offline   Reply With Quote
Old 01-15-2021, 10:36 AM   #367
Junior Member
 
Join Date: Jan 2021
Posts: 8
Hey I have an issue with my allison 1000. It drives good for like 30 miles or so and then I get the temp light on and goes on limp mode. Now the engine temp is like 190 no even close to 200. Fluid seems good, no smell or anything. Thanks
Seynel8228 is offline   Reply With Quote
Old 01-15-2021, 11:32 AM   #368
Senior Member
 
Arch Hoagland's Avatar
 
Monaco Owners Club
Workhorse Chassis Owner
Join Date: Aug 2002
Location: Clovis, CA, USA
Posts: 10,315
Quote:
Originally Posted by Seynel8228 View Post
Hey I have an issue with my allison 1000. It drives good for like 30 miles or so and then I get the temp light on and goes on limp mode. Now the engine temp is like 190 no even close to 200. Fluid seems good, no smell or anything. Thanks
What year is it?

Have you ever changed the transmission fluid and filter?
__________________
2004 Monaco La Palma 36DBD, W22, 8.1, 7.1 MPG
2000 LEXUS RX300 FWD 22MPG 4020 LBS
"All the truth in the world adds up to one big lie" Bob Dylan
Arch Hoagland is offline   Reply With Quote
Old 01-16-2021, 08:41 AM   #369
Junior Member
 
Join Date: Jan 2021
Posts: 8
Travel supreme 2001 spartan chassis 5.9l cummins 1000 allison. The previous owner said he pay someone to do the service but I'll said that someone don't know to much. The filter he used on the quietpact genset napa brand wasn't the right the treat was to short and it spit it out first time it starts. I'll said, I better change oil to transynd and new filters and seal. How do I know if the filter is deep or shallow pan? Everything seems to be factory. Thanks for the help
Seynel8228 is offline   Reply With Quote
Old 01-16-2021, 09:11 AM   #370
Senior Member
 
Mr_D's Avatar
 
Country Coach Owners Club
Winnebago Owners Club
Solo Rvers Club
iRV2 No Limits Club
Join Date: May 2011
Location: Vancouver, WA
Posts: 37,153
Quote:
Originally Posted by Seynel8228 View Post
Travel supreme 2001 spartan chassis 5.9l cummins 1000 allison. The previous owner said he pay someone to do the service but I'll said that someone don't know to much. The filter he used on the quietpact genset napa brand wasn't the right the treat was to short and it spit it out first time it starts. I'll said, I better change oil to transynd and new filters and seal. How do I know if the filter is deep or shallow pan? Everything seems to be factory. Thanks for the help
Doesn't the Allison 1000 have an external spin on filter?
__________________
2009 45' Magna 630 w/Cummins ISX 650 HP/1950 Lbs Ft, HWH Active Air
Charter Good Sam Lifetime Member, FMCA, SKP
RV'ing since 1957, NRA Benefactor Life, towing '14 Jeep JKU Dragon Edition
Mr_D is offline   Reply With Quote
Old 01-16-2021, 09:14 AM   #371
Senior Member
 
Chargerman's Avatar
 
Monaco Owners Club
Join Date: Nov 2015
Posts: 1,643
Yes a 1000 series has an external spin on cartridge filter.
__________________
Steven & Laurie
2006 Moncaco Executive Rainier
Detrioit Series 60 (515HP), Allison 4000 series
Chargerman is offline   Reply With Quote
Old 01-16-2021, 09:31 AM   #372
Junior Member
 
Join Date: Jan 2021
Posts: 8
I have a external spin filter. What you recommend transynd or mobile delvac. Can find transynd on any local store. The closes is 45 miles away and those guys want 67 dollars a gallon vs 41 for mobil at Walmart.
Seynel8228 is offline   Reply With Quote
Old 01-16-2021, 06:43 PM   #373
Senior Member
 
Chargerman's Avatar
 
Monaco Owners Club
Join Date: Nov 2015
Posts: 1,643
Buy whatever brand you can find to be the cheapest as long as it has the TES 295 approval. Any brand with this certification is the same as Transynd
__________________
Steven & Laurie
2006 Moncaco Executive Rainier
Detrioit Series 60 (515HP), Allison 4000 series
Chargerman is offline   Reply With Quote
Old 01-17-2021, 10:32 AM   #374
Member
 
Join Date: Oct 2018
Posts: 41
Quote:
Originally Posted by Seynel8228 View Post
I have a external spin filter. What you recommend transynd or mobile delvac. Can find transynd on any local store. The closes is 45 miles away and those guys want 67 dollars a gallon vs 41 for mobil at Walmart.
I bought Mobil Delvac online at Summit Racing for $34/Gal.
https://www.summitracing.com/parts/m...BoCsN4QAvD_BwE
Hoof-hearted is offline   Reply With Quote
Reply

Tags
allison



Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


Similar Threads
Thread Thread Starter Forum Replies Last Post
HI, 1.5 years to retirement 2 years till full time? Opimax New Member Check-In 10 03-21-2018 09:33 PM
Allison tech on the way HD4Mark Allison Transmission Forum 9 05-20-2015 05:40 AM
Are there some "must have" years or "no way" years for a Beaver Patriot Thunder? ie2special Monaco Owner's Forum 6 04-12-2014 05:19 PM
Allison transmission tech support thread Beagle RC Air Alpine Coach Owner's Forum 1 07-12-2007 07:34 AM
56 tech tips after FT for 3 years Henry Lahore Full-Timers 4 07-18-2005 08:12 AM


All times are GMT -6. The time now is 06:35 AM.


Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2021, vBulletin Solutions, Inc.