|
10-25-2021, 12:52 PM
|
#1
|
Senior Member
Join Date: Mar 2019
Location: Arizona
Posts: 2,239
|
Condenser fans not running when a/c is on
The Workhorse Chassis Guide says that the cooling fans should run continuously when the a/c is on or any time that the coolant temperature exceeds 221 degrees. Mine do run when the coolant temp climbs, but not when I turn the a/c on. Any ideas about where to look? I'm thinking there must be a bad pole on a switch or maybe a loose connection.
__________________
2004 National Dolphin LX 6320, W-22, 8.1, Allison 1000, Front/rear "Trac" Bars & Anti-sway Bars, Sumo Springs, Roadmaster Reflex Steering Stabilizer, 2005 PT Cruiser Toad
|
|
|
|
Join the #1 RV Forum Today - It's Totally Free!
iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!
You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!
|
10-25-2021, 12:56 PM
|
#2
|
Community Administrator
Tiffin Owners Club
Join Date: Sep 2013
Location: DFW, Texas
Posts: 21,526
|
I had the same issue with our Workhorse. The service company I used wound up having to wire in a relay connected to the A/C compressor wiring so the fans would run any time the compressor ran.
__________________
2017 Phaeton 40IH XSH Maroon Coral - Power Glide Chassis with IFS
Previous '15 Tiffin Allegro RED 38QRA and '06 Itasca Sunrise 35A
'16 Jeep JKU Wrangler Sahara or '08 Honda Goldwing
|
|
|
10-25-2021, 02:54 PM
|
#3
|
Senior Member
Join Date: Mar 2019
Location: Arizona
Posts: 2,239
|
Thanks for the tip, Lt Dan. That might be a good solution if all else fails.
So is there one large fan for cooling the engine and then two smaller fans for the a/c condenser, or just the two smaller fans for both? Sorry, my coach is not here at present or I'd just go out and look for myself.
__________________
2004 National Dolphin LX 6320, W-22, 8.1, Allison 1000, Front/rear "Trac" Bars & Anti-sway Bars, Sumo Springs, Roadmaster Reflex Steering Stabilizer, 2005 PT Cruiser Toad
|
|
|
10-25-2021, 07:30 PM
|
#4
|
Senior Member
Join Date: Mar 2019
Location: Arizona
Posts: 2,239
|
So now I'm not sure what to think. I took the Dolphin in last week to have the air conditioning serviced. They found that it was low on refrigerant and were the ones that told me that the fans weren't working when the a/c was on. This didn't surprise me as the a/c would blow warm when in traffic. They checked for blown fuses, didn't find any, and then called me to see if I wanted to pay them to troubleshoot wiring. Knowing that this could take hours I decided that was a job I'd rather do myself, so I paid them for the work they had done (recharging the system and checking for leaks) and picked up the motorhome.
The a/c worked fine on the way back to the storage yard. Once there, while walking passed the front of the motorhome (with the engine running and the a/c on) I could hear what sounded like the fans running. Sure enough, I looked through the grill and could see that the two small fans were indeed spinning. Scan gauge told me that the coolant temp was 200 degrees, not enough to turn the fans on according the Workhorse Chassis manual.
My question is, could recharging the system have caused the fans to start working again, or should I be looking for an intermittent connection?
__________________
2004 National Dolphin LX 6320, W-22, 8.1, Allison 1000, Front/rear "Trac" Bars & Anti-sway Bars, Sumo Springs, Roadmaster Reflex Steering Stabilizer, 2005 PT Cruiser Toad
|
|
|
10-25-2021, 08:25 PM
|
#5
|
Senior Member
Join Date: Aug 2020
Location: Ohio
Posts: 2,353
|
Yes.. if you were low on refrigerant.. then fans would not come on.. unless eng about 220 or so.. and if a/c system is full of refrigerant then fans come on as soon as a/c is turned on.. for verification.. go to nearest auto parts store and grab a book for basic automotive air conditioning repair book.. and it will explain in detail why.. great addition to the rv library
Good luck and let us know what you did and maybe better members then me will help you
__________________
2000 southwind storm, workhorse custom chassis with 7.4l vortec
|
|
|
10-25-2021, 08:48 PM
|
#6
|
Senior Member
Join Date: Mar 2019
Location: Arizona
Posts: 2,239
|
Quote:
Originally Posted by donr103
Yes.. if you were low on refrigerant.. then fans would not come on.. unless eng about 220 or so.. and if a/c system is full of refrigerant then fans come on as soon as a/c is turned on.. for verification.. go to nearest auto parts store and grab a book for basic automotive air conditioning repair book.. and it will explain in detail why.. great addition to the rv library
Good luck and let us know what you did and maybe better members then me will help you
|
Ok, that's good news then. Thanks for the information. Not sure why it was low on refrigerant if it doesn't have a leak (they tested it with nitrogen) but I suppose it's possible that the mobile tech I used last year to replace the compressor didn't add enough refrigerant.
All that's left to do now is clean the dead bugs off the condenser from the last trip.
__________________
2004 National Dolphin LX 6320, W-22, 8.1, Allison 1000, Front/rear "Trac" Bars & Anti-sway Bars, Sumo Springs, Roadmaster Reflex Steering Stabilizer, 2005 PT Cruiser Toad
|
|
|
10-26-2021, 03:27 AM
|
#7
|
Senior Member
Join Date: Jun 2016
Location: SW Louisiana
Posts: 8,945
|
My understanding is that those fans are controlled by an air conditioner pressure switch, not a temperature switch, as their primary function is to regulate air conditioner head pressure.
__________________
2002 Safari Trek 2830 on P32 Chassis with 8.1L w/ 400 watts solar 420Ah LiFePo4
2017 Jeep Cherokee Overland & 2007 Toyota Yaris TOADs with Even Brake,
Demco Commander tow bar and Blue Ox / Roadmaster base plates
|
|
|
10-26-2021, 06:25 AM
|
#8
|
Senior Member
Join Date: Nov 2018
Location: Fulda, MN
Posts: 1,248
|
What Isaac1 said. They are controlled by the high pressure switch, otherwise they would run needlessly on the road. So far as not cooling much when in traffic it is pretty much the consensus on this forum that you will not get much cooling when in slow traffic or sitting at a stop light. It sucks but it is what it is.
__________________
2000 Winnebago Adventurer 32v, P32 Workhorse Chassis with 01/2000 build date with factory wide track front end, 7.4l Vortech, J71 Ultra RV upgraded 67,000 miles
|
|
|
10-26-2021, 08:48 AM
|
#9
|
Senior Member
Join Date: Jun 2000
Location: Martinez, CA. USA
Posts: 362
|
Quote:
Originally Posted by CamJam1
Ok, that's good news then. Thanks for the information. Not sure why it was low on refrigerant if it doesn't have a leak (they tested it with nitrogen) but I suppose it's possible that the mobile tech I used last year to replace the compressor didn't add enough refrigerant.
All that's left to do now is clean the dead bugs off the condenser from the last trip.
|
On my AC system, I would have to add refrigerant on a yearly basis. Even had a shop check the system. Nothing found.
I started checking the system myself and found the Low Pressure switch was loose so I snugged it up. Also checked and found the low pressure port valve stem was leaking so I snugged that up also.
I added some refrigerant from a can and I am going on three years of no leaks and cold air when I need it.
I found the low pressure switch leak because of an accumulation of oil and dirt around the fitting. The other leak was found with soap and water.
The AC system is a closed system and if there is a lack of refrigerant then there is a leak somewhere.
|
|
|
10-26-2021, 10:06 AM
|
#10
|
Senior Member
Join Date: Mar 2019
Location: Arizona
Posts: 2,239
|
Quote:
Originally Posted by David 70
What Isaac1 said. They are controlled by the high pressure switch, otherwise they would run needlessly on the road. So far as not cooling much when in traffic it is pretty much the consensus on this forum that you will not get much cooling when in slow traffic or sitting at a stop light. It sucks but it is what it is.
|
Not disagreeing that fans are controlled by the pressure switch, but they are also designed to come on when coolant temp reaches 221 degrees. The pressure switch would sure explain the fans not operating when refrigerant was low though.
__________________
2004 National Dolphin LX 6320, W-22, 8.1, Allison 1000, Front/rear "Trac" Bars & Anti-sway Bars, Sumo Springs, Roadmaster Reflex Steering Stabilizer, 2005 PT Cruiser Toad
|
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|