|
04-10-2022, 06:56 PM
|
#1
|
Junior Member
Join Date: Jan 2021
Posts: 20
|
Campsite 911 on Hot Water Heater not working
I've got a Keystone water heater model WH-6GEA that stopped working on both electric and gas hot water. Initially got it down to the 2 amp fuse that looked discolored and replaced it with a new 2 amp fuse, and same issue with no hot water. Was hoping to solicit Old Biscuit or any others that may be able to give some advice.
Thanks!!
|
|
|
|
Join the #1 RV Forum Today - It's Totally Free!
iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Do you need advice on what products to buy? Or maybe you can give others some advice? No matter where you fit in you'll find that iRV2 is a great community to join. Best of all it's totally FREE!
You are currently viewing our boards as a guest so you have limited access to our community. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!
|
04-10-2022, 08:21 PM
|
#2
|
Senior Member
Join Date: Nov 2015
Posts: 26,845
|
Thermal Fuse....device in the Clear Tubing just above the burner/combustion chamber
But also wedged in just below the Exhaust Shield on that Dmoetic WH-6GEA
Thermal Fuse is a one shot fuse that blows when exposed to 190*F....safety device to stop Flame Blow Back
BUT Dometic wedged it in where Exhaust temps can cause it to blow
Unplug it from the t-stat and Brown Wire
Plug Brown wire back onto T-stat and try gas operation
If it fires up....Thermal Fuse
__________________
I took my Medication today. HAVE YOU?
Dodge 3500 w/Tractor Motor
US NAVY---USS Decatur DDG-31
|
|
|
04-10-2022, 09:04 PM
|
#3
|
Junior Member
Join Date: Jan 2021
Posts: 20
|
Thanks for the advice and response on this! Will give it a go!
__________________
2021 Keystone Premiere 26RBPR
2020 Chevy 1500 Silverado 5.3L V8 4WD
|
|
|
04-10-2022, 09:17 PM
|
#4
|
Junior Member
Join Date: Jan 2021
Posts: 20
|
OMG!! It fired up!! There's FIRE in the hole!! OB Sir, you ARE The JEDI Master!! THANK YOU SIR!!!
__________________
2021 Keystone Premiere 26RBPR
2020 Chevy 1500 Silverado 5.3L V8 4WD
|
|
|
04-10-2022, 09:26 PM
|
#5
|
Senior Member
Join Date: Nov 2015
Posts: 26,845
|
Fire good...hot water even better!
Thanks for update!
Thermal Fuse...
Great idea/poor engineering on location
Atwood Models had it out in open so that only flame blow back affected it
Dometic relocated the AC Element to front/outside compartment which required a new design which ended up with stacked combustion/exhaust chambers hence the thermal fuse trapped in between
Note of worthy: Suburban doesn't use a Thermal Fuse...never have
Flame blow back is RARE and is due to obstructed combustion/exhaust 'U' tube
Sooooo??
__________________
I took my Medication today. HAVE YOU?
Dodge 3500 w/Tractor Motor
US NAVY---USS Decatur DDG-31
|
|
|
04-10-2022, 10:06 PM
|
#6
|
Junior Member
Join Date: Jan 2021
Posts: 20
|
And I corrected the auto spell to what I originally wanted it to say, concerning your sage advice! And yes, the Hot Water is a Game Changer, for sure! :-)
__________________
2021 Keystone Premiere 26RBPR
2020 Chevy 1500 Silverado 5.3L V8 4WD
|
|
|
04-11-2022, 07:04 AM
|
#7
|
Senior Member
Join Date: Jan 2021
Location: Independent Republic of Horry
Posts: 560
|
So is the thermal fuse actually good for anything other than the annoyance factor?
__________________
2018 Ram 1500, 2020 Cougar 22RBS
Just the 2 of us and 2 Jacks on the roam.
Meet us at Olympus Mons. Gone Traveling.
|
|
|
04-11-2022, 07:16 AM
|
#8
|
Senior Member
Join Date: Oct 2014
Posts: 7,882
|
Quote:
Originally Posted by Martian
So is the thermal fuse actually good for anything other than the annoyance factor?
|
Yes, it is there to keep your RV from burning down in the event of a catastrophic over-heat in the water heater.
__________________
Brett Wolfe
Ex: 2003 Alpine 38FDDS. Ex: 1997 Safari Sahara. Ex: 1993 Foretravel U240
|
|
|
04-11-2022, 12:06 PM
|
#9
|
Senior Member
Join Date: Nov 2015
Posts: 26,845
|
Quote:
Originally Posted by wolfe10
Yes, it is there to keep your RV from burning down in the event of a catastrophic over-heat in the water heater.
|
Flame Blow Back 'protection' which can/could/possibly occur if combustion/exhaust chamber was obstructed
Note...Suburban Water heaters do NOT have a thermal fuse and hard to find any documented case of flame blow back burning down/causing damage
Point is.....flame blow back will melt the Brown wire and stop all operation.
ECO/HI temp T-stat trips if overheating and T&P Relief Valve pops open if t-stat/ECO fails
Soooooooo!
__________________
I took my Medication today. HAVE YOU?
Dodge 3500 w/Tractor Motor
US NAVY---USS Decatur DDG-31
|
|
|
04-11-2022, 02:23 PM
|
#10
|
Senior Member
Join Date: Jan 2021
Location: Independent Republic of Horry
Posts: 560
|
Aha! Common sense thrown into the picture. Is there a better place to locate the thermal fuse where it would only work as intended or is it really just an engineering holdover that no bean counters have discovered yet?
__________________
2018 Ram 1500, 2020 Cougar 22RBS
Just the 2 of us and 2 Jacks on the roam.
Meet us at Olympus Mons. Gone Traveling.
|
|
|
04-11-2022, 07:12 PM
|
#11
|
Senior Member
Join Date: Nov 2015
Posts: 26,845
|
Quote:
Originally Posted by Martian
Aha! Common sense thrown into the picture. Is there a better place to locate the thermal fuse where it would only work as intended or is it really just an engineering holdover that no bean counters have discovered yet?
|
Not on the Dometic WH-6GEA model.
Atwood has had thermal fuse on every model/version
Suburban has never had a thermal fuse
Basically the same water heaters but different concepts.
__________________
I took my Medication today. HAVE YOU?
Dodge 3500 w/Tractor Motor
US NAVY---USS Decatur DDG-31
|
|
|
04-11-2022, 07:15 PM
|
#12
|
Senior Member
Monaco Owners Club Workhorse Chassis Owner
Join Date: Aug 2002
Location: Clovis, CA, USA
Posts: 13,151
|
What does Campsite 911 mean?
__________________
2004 Monaco La Palma 36DBD, W22, 8.1, 7.1 MPG
2000 LEXUS RX300 FWD 22MPG 4020 LBS
Criticism is easier than Craftsmanship
|
|
|
04-11-2022, 07:17 PM
|
#13
|
Senior Member
Join Date: Nov 2015
Posts: 26,845
|
Quote:
Originally Posted by Arch Hoagland
What does Campsite 911 mean?
|
HELP!
__________________
I took my Medication today. HAVE YOU?
Dodge 3500 w/Tractor Motor
US NAVY---USS Decatur DDG-31
|
|
|
|
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Discussions |
|
|
|
|
|
|
|
|
|
|
|
|
|